Product ID:FX-2 CARTRIDGE BLACK, H11-6321-220
MSDS Date:12/01/1993
FSC:6850
NIIN:00N061508
MSDS Number: BXZWC

CANON USA INC

ONE CANON PLAZA
LAKE SUCCESS, NY 11042
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 516-488-6700

Cage: 1BA63

CANON USA INC

LAKE SUCCESS, NY 11042 US

Telephone: 516-328-5600

Cage: 1BA63

STYRENE ACRYLATE COPOLYMER; (PROPRIETARY INGREDIENT)

Fraction By Weight: 45-55%

OSHA PEL N/K

ACGIH TLV: N/K

IRON OXIDE

CAS: 1317-61-9

Fraction By Weight: 45-55%

OSHA PEL 10 MG/M3

ACGIH TLV: 5 MG/M3

LD50 LC50 Mixture:LD50 (ORAL RAT): > 5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL/SKIN: EXPECTED TO BE A
LOW HAZ FOR REC HNDLG. EYES: MAY CAUSE TRANSIENT IRRIT. INGEST:
EXPECTED TO BE LOW INGEST HAZ. CHRONIC: BASED UPON AVAIL DATA,
HUMAN EXPOS TO TONER HAS BEEN SHOWN T O CAUSE MIN RESP TRACT IRRIT
AS MAY OCCUR W/LGE AMTS OF ANY NONTOX DUSTS. RSLTS OF ONE ANIMAL
STUDY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: WHERE RATS INHALED TONER TEN TIMES
MORE RESP THAN COMMERCIALY AVAIL TONER WERE OBSERVED TO HAVE NO
LUNG CHANGES AT LOW EXPOS (THE MOST RELEVANT LEVEL TO POTENTIAL
HUMAN EXPOS). AT HIGHER LEV ELS A SLIGHT DEGREE OF LUNG FIBROSIS
WAS OBSERVED DUE TO EXCESS AMTS OF DUST RETAINED IN LUNGS FOR PRLNG
INTERVAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: ANY MATERIAL THAT CONTACTS THE
EYES SHOULD BE WASHED OUT IMMEDIATELY WITH WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION:
DRINK ONE OR TWO GLASSES OF WATER. NO ADVERSE EFFECTS EXPECTED.

Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO*2), DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER MATERIAL, LIKE MOST ORGANIC
MATERIAL IN POWDERED FORM, IS CAPABLE OF CREATING A DUST EXPLOSION.

Spill Release Procedures:SWEEP MATERIAL ONTO PAPER AND PLACE IN A FIBER
CARTON.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID BREATHING DUST. USE WITH
ADEQUATE VENTILATION. KEEP FROM CONTACT WITH OXIDIZING MATERIALS.
MINIMIZE DUST GENERATION AND ACCUMULATION.
Other Precautions:REFER TO PAMPHLET #654, "PREVENTION OF FIRE AND DUST
EXPLOSIONS IN THE CHEMICAL, DYE, PHARMACEUTICAL AND PLASTICS
INDUSTRIES". KEEP CONTAINER CLOSED.

Respiratory Protection:NONE SHOULD BE NEEDED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CNDTNS.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. GOOD HYGIENE
PRACTICE SHOULD BE FOLLOWED WHICH INCLUDES PREVENTING EYE CONT,
(SUP DAT)
Supplemental Safety and Health
WASTE DISP METH: SEE "CANON CLEAN EARTH CAMPAIGN". HYGIENE PRACT:
MINIMIZING SKIN CONTACT, INHALATION.

Melt/Freeze Pt:M.P/F.P Text:>212F,>100C
Spec Gravity:1.5-1.8(H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK SOLID POWDER, WITH SLIGHT PLASTIC ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.

Waste Disposal Methods:INCIN/LANDFILL. CAN BE INCIN WHEN IN COMPLIANCE
W/LOC, STATE, & FED REGS. DISCHARGE, TREATMENT/DISP MAY BE SUBJECT
TO NATIONAL, STATE/LOC LAWS. CARTRIDGE MAY BE DISP OF AS PLASTIC
WASTE. MFR REC RECYC LING OF EXHAUSTED CARTRIDGE. (SUP DAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.